Fixing cracked flue tiles in Lauderdale West

Open flues are sheeted over before we come off the roof each day, and debris is hauled away.

Owned and run locally
Available for same-day service
Fully licensed and insured
Family owned and run

Call Now (645) 465-4171 Book Online

Why people ask about flue repair

Clay pieces on the firebox floor
A note about the lining from an earlier visit
Smoke odor near the chimney wall
A planned change of appliance or fuel

Jump to

What goes into a sound flue repair

Movement cracks in a clay lining

Settling and other movement in the house can crack a clay lining, because the tiles are rigid and the chimney around them shifts. Cracks from movement may line up with cracks in the outer masonry. That pattern matters for the repair.

If the movement is ongoing, repairing the tile alone may not last. We look for related cracks outside the flue and explain what they suggest. Where a structural question arises, it is raised plainly and kept separate from the lining repair in the estimate. Movement that has stopped is a different case from movement that continues.

The final check after a flue repair

When the repair material is in place, the flue is checked along its length as far as it can be seen. Repair instructions call for that final look, to confirm the material covers the sections it was meant to cover.

We tell you what the final check showed and note it in the written record. If a section could not be seen after the repair, as before, that is stated. The record then gives you and any later visitor an honest picture of the flue. Any area that looks thin or missed is dealt with before we pack up.

Where removed tile and mortar go

Flue repair produces debris: broken tile, mortar ridges, old patches and cleaning residue. Most of it comes down through the fireplace or is lifted out at the top. It is collected as the work goes.

Debris is cleaned up and hauled away when the work is done. The fireplace area is left clean at the end of each day. If any material is kept for you to see, such as the broken top tile, we set it aside and show you. The firebox and hearth are wiped down before we leave.

Water through a cracked crown reaching the tiles

A cracked crown can let rain reach the outside of the upper tiles and the masonry around them. Water there can loosen joints from the outside while the flue itself looks intact from below.

We look at the crown while we examine the top of the flue. If it is letting water in, repairing the tiles alone leaves the cause in place. Crown repair is quoted as its own item, and we explain whether it should come before the flue work. Fixing both in one visit is possible, and each stays priced separately.

Your free inspection before flue repair in Lauderdale West

Defects located from top and bottom
Mortar ridges cut back from the passage
Bond break restored at the crown
Chimney top covered at each day's end

Questions to settle before a flue repair

Can you replace just the top tile of my flue?

Often, yes. The top tile is reachable from the roof and can be replaced on its own if the tiles below are sound. We check below it first and restore the bond break where the tile passes through the crown.

Will repairing the flue stop water coming into the fireplace?

Not by itself. Water can enter through the crown, the masonry, the flashing or an open flue top. We trace the likely path first, using a hose water test only when the job calls for it, and quote the fix for the source.

What do I receive when the flue repair is finished?

A written record of the work naming the flue, the defects found, the method and product used, the sections treated and any items left for later. It also carries the curing guidance for the product.

Proudly American

Local service. Careful repairs. A fireplace worth coming home to.

Call Now (645) 465-4171

Book Your Free Inspection in Miami

(645) 465-4171

Chimney & Fireplace Brands We Work With

DuraVent
Olympia Chimney and Venting
Copperfield Chimney Supply
Rutland
Heatilator
Heat & Glo